Tool kit for car

[Geeman]

Hi everyone, im putting together a permanent tool kit to keep in my car (94 Range Rover Classic V8) soon to be 300tdi.
So far I have:

#Tool Bag
#1/2" socket set
#1/4" socket set
#metric 6mm to 32mm spanner set open/ring
#metric allen key set
#bacho 4 piece file kit
#32oz Ball Pene Hammer
#Small Mash Hammer
#wheel bearing hub socket
#Screw Driver Set

what else should I include in my kit

cheers Goran

[91ramjet]

Hi
shifter. zip ties. sidecutters

[MR LR]

2 x 9/16 (i'm pretty sure) combination spanners for the flanges on the tailshaft to take them off if need be

[JC Rover]

A cheap hack saw is very handy to have around, as is a 12 volt multi meter.

JC

[bee utey]

Aviation tin snips, old 12v battery drill adapted to run off the car battery, self tapping/tek screws, a modest amount of zinc plated sheet steel or ally, silicone sealant. You'd be amazed how much you can fix on an exhaust system with a bit of tin. Also good for fixing damaged panels enough to get home.

[richard4u2]

roll of wire and good pair pliers

[Ausfree]

A roll of Duck tape can come in handy!!:D

[Homestar]

I never let the missus go anywhere in hers without RACV Platinum Membership...:p

[dobbo]

I never let the missus go anywhere in hers without RACV Platinum Membership...:p


Personally I'd prefer a roll of gaffa tape,

my kit also includes

WD40
jumper cables and a few welding sticks
two extra 9 1/16 ring spanners,
stilsons wrench
roll of electrical wire
spare tyre tube and rust ring,
rust rings can be cut up and bodged to make anything from temporary suspension bushes to insulating electrical faults
high lift jack
piece of galvanized pipe with a diameter big enough to sleeve any steering arms on the vehicle
axe
steel zip ties
a roll of poly rope (considering what it is the tensile strength is amazing)
roll of dunny paper, and baby wipes
billy, matches and tea bags
bottle of rum

[Tank]

A roll of Duck tape can come in handy!!:D
How do tape up a Duck, LOL, Regards Frank.

[superquag]

I never let the missus go anywhere in hers without RACV Platinum Membership...:p

YES

[superquag]

A roll of Duck tape can come in handy!!:D

'Duct' - Grey plastic tape that stretches and conforms. Very sticky, minimal creep when applied. Designed for HVAC fitters installind & joining air .... ducts...:p:p.

[Geeman]

Im planing on ordering one of these sockets to undo tail shaft bolts

eBay Australia: Buy new & used fashion, electronics & home d (http://www.ebay.com.au/itm/370515052256'ssPageName=STRK:MEWAX:IT&_trksid=p3984.m1423.l2649)

anyone have one of them? Im also looking at ordering one of those viscous fan removal spanners 32mm-36mm. I know you get so much more room to work on things when you remove the fan!!!


Anyone keep the 2part putty that turns to steel?

[superquag]

2 x 9/16 (i'm pretty sure) combination spanners for the flanges on the tailshaft to take them off if need be

Correct. but not 'if', - 'when' the VC packs up and you need to remove the front prop shaft.

(assuming you don't transplant the 300's gearbox/LT230 ...)

[91ramjet]

Hi
i not long ago put a 200tdi in my classic best thing i ever did. let us know if you want any info regarding conversion.
cheers. jake

[richard4u2]

a good galvanized covered trailer to put every thing in :angel:

[MR LR]

a good galvanized covered trailer to put every thing in :angel:
With the lists some of these guys have you'd need it, all of dad's tols fit in a lunchbox thing, he was a Land Rover dealer and had every tool he ever needed on any car (including our veteran cars), if we went offroad he'd take extra but as an everyday tool kit he had enough i should pull it out and record whats in it :)

[Geeman]

a good galvanized covered trailer to put every thing in :angel:

I think im gonna have to buy a bigger tool bag:eek:

[Geeman]

Hi
i not long ago put a 200tdi in my classic best thing i ever did. let us know if you want any info regarding conversion.
cheers. jake

I just started on the conversion, I bought a 1994 300tdi disco, Ive pulled the entire drive-line, fuel system, wiring loom and pretty much everything else I need from it, Ive cut the engine mounts off and now i'm in the process of trying to organsie all the parts, Ive got parts scattered everywhere. Cant bloody find anything!!!

If I run into any troubles I will yell out.

cheers Goran

[dobbo]

I think im gonna have to buy a bigger tool bag:eek:


apart from the pipe and high lift all of my stuff fits in the toolbox under the drivers seat of the county

[Ausfree]

Ok, you lot, you know what I mean Duck tap.....Duct tape......Gaffer tape, you know that handy stuff that is good for temporary repairs when a bumper bar falls of or a mudguard falls off!!:tease::D:D

[MR LR]

Ok, you lot, you know what I mean Duck tap.....Duct tape......Gaffer tape, you know that handy stuff that is good for temporary repairs when a bumper bar falls of or a mudguard falls off!!:tease::D:D
Nah i just finish the job and chuck them in the back haha ;)

[Davo]

Duck tape - so named because when it was invented during WWII it was made with adhesive and a material called cotton duck. Now, that's from memory because it's late and I can't be bothered to look it up, but I know someone else here will!

[460cixy]

Im planing on ordering one of these sockets to undo tail shaft bolts

eBay Australia: Buy new & used fashion, electronics & home d (http://www.ebay.com.au/itm/370515052256'ssPageName=STRK:MEWAX:IT&_trksid=p3984.m1423.l2649)

anyone have one of them? Im also looking at ordering one of those viscous fan removal spanners 32mm-36mm. I know you get so much more room to work on things when you remove the fan!!!


Anyone keep the 2part putty that turns to steel?



I got the prop tool best thing ever halves the time to get a shaft out easy

[Geeman]

I got the prop tool best thing ever halves the time to get a shaft out easy

I've take the tailshafts off on two rangies and a disco and there all bloody tight as!! I also busted a cheap spanner on those bolts aswell. I will definantly be ordering that and the viscous coupling spanner very soon.

[MR LR]

I find you need single hex (socket) otherwise they are a real PITA, ground down ring spanners seem to work well though

[digger]

Duck tape - so named because when it was invented during WWII it was made with adhesive and a material called cotton duck. Now, that's from memory because it's late and I can't be bothered to look it up, but I know someone else here will!


and sure enough... :D

from Duct Tape vs. Duck Tape - an explanation (http://www.octanecreative.com/ducttape/duckvsduct.html)

Dear Duct Tape Users:

Is it Duct or Duck? We don’t want you to be confused, so we will explain. The first name for Duct Tape was DUCK. During World War II the U.S. Military needed a waterproof tape to keep the moisture out of ammunition cases. So, they enlisted the Johnson and Johnson Permacel Division to manufacture the tape. Because it was waterproof, everyone referred to it as “duck” tape (like water off a duck’s back).

Military personnel discovered that the tape was good for lots more than keeping out water. They used it for Jeep repair, fixing stuff on their guns, strapping equipment to their clothing... the list is endless.

After the War, the housing industry was booming and someone discovered that the tape was great for joining the heating and air conditioning duct work.

So, the color was changed from army green to the silvery color we are familiar with today and people started to refer to it as “duct tape*.” Therefore, either name is appropriate.




--------------------------------------------------------------------------------
Duct Tape by Any Other Name (is just as sticky)

As a public service to Duct Tape Novices and Pros alike, here is a short list to acquaint you with some other names given to “The Ultimate Power Tool.”

Gaff Tape (also Gaffer’s Tape): This special grade of duct tape (often colored black) was developed by the entertainment industry to hold lighting equipment and cables in place and has a dull finish so that it won’t reflect lights. Gaff Tape also has a specially formulated, less tacky adhesive that won’t leave a residue when it is removed.

Spike Tape: The thin rolls (1/2 inch wide) of many colors used in theatres to stick on the stage so actors can find their mark or stagehands know where to set the scenery. It is usually the matte finish gaff tape type.

Rock and Roll Tape: Whether they can afford gaff tape or just good old black duct tape, underappreciated rock and roll roadies keep the music industry alive thanks to their love of the America’s favorite adhesive.

100 MPH Tape: A name recognizable, no doubt, to U.S. Army Veterans.

200 MPH TAPE: Pit crews across the nation’s auto-racing circuit know that duct tape holds even when you’re going over 200 M.P.H. The nickname was so common, “Duck” brand duct tape manufacturer Manco has even trademarked it!

1,000 M.P.H. tape: The U.S. Navy uses duct tape to repair radomes. A Radome is the dome that fits over a radar antenna. On an airplane, that's usually the nose cone. It has to be transparent to the radar waves. (Any repairs must be radar-transparent, too on fighter aircraft.) Since the planes fly so darn fast, they call it “thousand mile an hour” tape.

Missile Tape: The Aerospace industry, according to a Martin Marietta worker, used a green duct tape that they secured and routed wiring and cables on test missiles. They called this green duct tape "missile tape".

1,000 Mile tape: Norman Vaughn, arctic explorer for whom Antarctica’s Mount Vaughn was named, puts it on his dog sled runners to prevent ice build-up and says it lasts 1,000 miles. He is also the one who recommends sleeping with the tape to keep the adhesive pliable in cold climates.

Canoeists’ Companion: Very few canoeists would be caught without a roll of duct tape. Why? Hit a rock, rip open the hull, you’re done canoeing unless you have duct tape along!

Wisconsin Pewter on a Roll: Any Packer fan will tell you what’s really keeping that cheese on their heads: duct tape.

Minnesota (or, insert your own rust-inducing state here) Chrome: In the land of lakes, snow, road salt, and rusty cars, they use duct tape a lot more often than they visit the auto body shop.

Hikers’ Helper: Along with a good sleeping bag, a Swiss Army knife, and dry matches, duct tape makes sure outdoors enthusiasts are prepared for anything.

Jesus Tape: In Finland and Sweden, they refer to duct tape as “Jesus Tape.” They also refer to it as Gaffer's tape (or "roudarin teippi" in Finnish).

Plastic Surgeon on Roll: Pulls skin tight, lifts and separates—we all look better with a little bit of duct tape.

First Aid Kit on a Roll: A great emergency substitute for splints, bandages, tourniquets, sutures, etc (see our HMO on a Roll page offering medicinal uses for duct tape - including endorsements by doctors and those in the health services professions).

[Ausfree]

The Finns and Swedes call it "Jesus Tape" eh!!!.......Cripes don't let John F see that!!!:eek: ( only joking John):D:D

[Davo]

Ha! I knew one of you forum addicts would do the hard work for me! (Thanks, by the way.) I just remembered that I have a wallet made of duct tape - a "Ducti".

Duck tape is great, but you really need to find a good brand. The stuff I have now doesn't like heat and will fall off, leaving a sticky mess behind. I see there's nothing on eBay here, so it looks like my next try will be the USA.

[MR LR]

Ha! I knew one of you forum addicts would do the hard work for me! (Thanks, by the way.) I just remembered that I have a wallet made of duct tape - a "Ducti".

Duck tape is great, but you really need to find a good brand. The stuff I have now doesn't like heat and will fall off, leaving a sticky mess behind. I see there's nothing on eBay here, so it looks like my next try will be the USA.
Just search the best brand on the internet, order a pallet and become a vendor :)

[Sleepy]

Probably getting off track (Recovery Gear?) but I always like to have a tow rope and a couple of shackles. :angel:

This usually stays in the car with the tools, whereas my recovery gear (snatch straps, tt protectors, winch ext,) is part of another kit.

I also have a small torch (Those cheap LED ones are fine) and a pair of gloves.

Also a small tarp, if you are a woos like me and don't like laying down in the mud. (Mine doubles as a shroud for river crossings)

[Geeman]

Yea got myself a full recovery kit that stays in the car all the time. But I gotta get me some duct tape!!:D