Results 1 to 3 of 3

Thread: Finally, found some.... rust

  1. #1
    Join Date
    Dec 2014
    Location
    FNQ
    Posts
    1,016
    Total Downloaded
    0

    Finally, found some.... rust

    Well I knew my ownership streak was simply too good to be believed.

    Only a matter of a few days ago I was skiting to a tradie acquaintance how darn reliable and worry-free my RRC ownership has been in comparison to others.

    Bite your tongue lad!

    So naturally I was giving the old bus a once-over with the gerni, which includes opening doors and doing jambs and sills etc and all the other places sydney funnelwebs like to hide... (and incidentally found one in between the rear left tailight and the ARB bar... and several huntsman that had taken up residence from the recent rains we had... it's a wonderful wildlife refuge)

    So... yep as I was giving it a very mild wash, the doors pavement illumination fell out. I thought oh yeah, old rubber, it's just loose... gave it a bit of a wipe over and then ran the gerni over the inner jamb area and you can imagine the horror.

    Well, I learned something. Something undisclosed to me when I purchased the vehicle. It's had a respray (ok what RRC pretty much hasn't) and the door isn't original. In fact It's sapphire blue... under the ardennes green. and the entire lower inside frame is PROPERLY rusted. As in "how the hell did I not see this years ago" - that's how bad it is.

    Anyway, long story short, I continued to wash the old bus down and after that was done came back to the door and decided to find out the true extent..... So I put the rotojet on the front (about 5Kpsi) and got personal... and I found some more holes in the inner skin about 10 inches below the striker plate, and a couple of blisters on the bottom where the skin folds over the inner.

    Now looking like I need a new door, and possibly more than one....

    The light was fading and I rand out of time, but it did not stop me from getting up close and personal with the gerni on a few other suspect imperfections / blisters.

    And yes, disappointment followed - which was to be expected.

    Now on the hunt for a passenger front door, actually, I think I should look for a complete set of doors TBH. I have no idea if any of them are good.

    It would seem that RRC doors are hard to come by. Anyone seen and late versions around? If you have let me know. (concealed hinges)

    Failing that, it may be possible to butcher an old door with a rusty skin or somesuch and try to patch one, but at this stage, I think complete doors would be a more straightforward solution.

    Me and my big bloody mouth.

    Bugger.
    Roads?.. Where we're going, we don't need roads...

  2. #2
    Join Date
    Feb 2013
    Location
    Ballarat,Vic,Aus
    Posts
    3,580
    Total Downloaded
    0
    Sounds all non-structural to me. Its certainly not the end of the world and can be fixed
    Proper cars--
    '92 Range Rover 3.8V8 ... 5spd manual
    '85 Series II CX2500 GTi Turbo I :burnrubber:
    '63 ID19 x 2 :wheelchair:
    '72 DS21 ie 5spd pallas
    Modern Junk:
    '07 Poogoe 407 HDi 6spd manual :zzz:
    '11 Poogoe RCZ HDI 6spd manual

  3. #3
    Join Date
    Jan 1970
    Location
    Two Rocks WA
    Posts
    1,334
    Total Downloaded
    0
    Hi my doors on the inside near the door lock assy have bubbles as well...one day I will fix...trying to get good doors without rust is gunna be hard...I have another 90 model Rangie at my mums house and it too has rust in the doors and almost no floor left....again..one day..sigh.
    I may cut out and fiberglass as a temp until I can get to my own Rangie...it is garaged at the moment so hopefully won’t get any worse, surprisingly my upper tailgate has no rust at all and is original!!!😁😁
    Range Rovers Have Charactors inside them
    LROCWA Ex member 23 years
    1971 Series 2A
    2004 Discovery2a V8 Auto
    2003 Discovery2a TD5 Manual
    1982 4door man (sadly now gone)
    1989 Vogue auto
    2011 TDV8 Vogue
    What would life be without a Rangie?



Tags for this Thread

Bookmarks

Bookmarks

Posting Permissions

  • You may not post new threads
  • You may not post replies
  • You may not post attachments
  • You may not edit your posts
  •  
Search AULRO.com ONLY!
Search All the Web!