Results 1 to 8 of 8

Thread: Auxiliary batteries - Golf buggy 6v in series vs 12v AGM's

  1. #1
    Join Date
    Aug 2011
    Location
    Hunter Valley NSW
    Posts
    291
    Total Downloaded
    0

    Auxiliary batteries - Golf buggy 6v in series vs 12v AGM's

    I'm just planning out the last of a long list of upgrades and came across a recommendation to run a pair of 6v golf buggy batteries in lieu of the 12v options for auxiliary power.

    A pair of 6v 225ah wired in series beats the snot out of a pair of 105ah 12v batteries. Both set ups would weigh the same.

    Seems too good to be true....costs aside what's the catch? There has to be one.

    Looking at what I need for our long term touring/camping set up and I'm leaning towards more batteries than solar to keep everything going. We don't hang around camp all day and almost will always be on the move every few days.

  2. #2
    Tombie Guest
    A serious combination of Solar and battery reserve will outdo battery banks hands down.

    Here’s my experience with this.

    2x 6v will have slightly thicker plates so may well work a bit better at deep discharge.

    However for a long term tourer (offroad) redundancy is king... if a 6v dies that’s it you’re done.
    If a 12v dies in a parallel you can just drop it out of the system.

    Other than that it all comes down to packaging.

  3. #3
    Join Date
    Jan 1970
    Location
    Queensland
    Posts
    7,768
    Total Downloaded
    0
    While I have used two 6v batteries in series, to get a 12v setup, I have to be honest, I a not a fan.


    Potential problems are:-


    If you have two 12v batteries in parallel and one dies, your still have a LIMITED 12v supply.


    If a 6v dies, you have lost the lot.


    If you are in the middle of nowhere and you lost one of your 12v batteries, any 12v battery, including substituting a deep cycle with a cranking battery, will get you back up to the capacity you need and you can get cranking batteries at most outback servos.


    If a 6v battery dies in the middle of nowhere, you not only have no battery power, but you may find it near impossible to get a replacement and the freight may bankrupt you.


    And the replacement MOST BE IDENTICAL, making getting a replacement that much harder.

  4. #4
    p38arover's Avatar
    p38arover is offline Major part of the heart and soul of AULRO.com
    Administrator
    I'm here to help you!
    Gold Subscriber
    Join Date
    Jan 1970
    Location
    Western Sydney
    Posts
    30,160
    Total Downloaded
    0
    I'm running two 12V 45Ah deep cycle AGM batteries (as used a mobility scooter) in parallel in my dual battery setup in the L322 - they fit in the space available under the floor whereas a 12v 100Ah battery wouldn't.
    Ron B.
    VK2OTC

    2003 L322 Range Rover Vogue 4.4 V8 Auto
    2007 Yamaha XJR1300
    Previous: 1983, 1986 RRC; 1995, 1996 P38A; 1995 Disco1; 1984 V8 County 110; Series IIA



    RIP Bucko - Riding on Forever

  5. #5
    Homestar's Avatar
    Homestar is offline Super Moderator & CA manager Gold Subscriber
    Join Date
    Aug 2010
    Location
    Sunbury, VIC
    Posts
    20,055
    Total Downloaded
    0
    Where did this info come from? - 'A pair of 6v 225ah wired in series beats the snot out of a pair of 105ah 12v batteries. Both set ups would weigh the same.'

    Energy density in a given format is similar, so the 2 x 6 volt batteries if they ran identical design, etc would be slightly heavier, and give you a little extra capacity, but that's because they are bigger batteries, so in series you end up with 12 volts and 225Ah, (remember your Ah capacity doesn't double to 450 like this, but remains the same at 225 - you only double your voltage when you connect them in series) but in reality not - they wouldn't discharge at an identical rate (close) but you'd lose a bit there, then as mentioned you lose one battery, the whole show is gone. Both batteries would need to be identical and of similar age too to even work to start with and not stuff one in a few hours of driving. If you are after the extra 20Ah, why not buy 2 x 12 volt, 110Ah batteries then you have exactly the same capacity with redundancy built in.
    If you need to contact me please email homestarrunnerau@gmail.com - thanks - Gav.

  6. #6
    Join Date
    Aug 2011
    Location
    Hunter Valley NSW
    Posts
    291
    Total Downloaded
    0
    Quote Originally Posted by Homestar View Post
    Where did this info come from? - 'A pair of 6v 225ah wired in series beats the snot out of a pair of 105ah 12v batteries. Both set ups would weigh the same.'

    Energy density in a given format is similar, so the 2 x 6 volt batteries if they ran identical design, etc would be slightly heavier, and give you a little extra capacity, but that's because they are bigger batteries, so in series you end up with 12 volts and 225Ah, (remember your Ah capacity doesn't double to 450 like this, but remains the same at 225 - you only double your voltage when you connect them in series) but in reality not - they wouldn't discharge at an identical rate (close) but you'd lose a bit there, then as mentioned you lose one battery, the whole show is gone. Both batteries would need to be identical and of similar age too to even work to start with and not stuff one in a few hours of driving. If you are after the extra 20Ah, why not buy 2 x 12 volt, 110Ah batteries then you have exactly the same capacity with redundancy built in.
    Buy Trojan T-105 - Trojan Deep Cycle Batteries

    Well that's the nail on the head.

    Bloody hell I should know better! That's the 'catch', need to smack myself up the side of the head....I'm a moron. I got way too excited at the outcome and not the why.

    ah @ 12v = wh/v

    ah @ 6v =wh/v

    1200/12=100ah

    1200/6= 200ah



  7. #7
    Join Date
    Mar 2007
    Location
    Warwick Qld
    Posts
    1,977
    Total Downloaded
    0
    Also, 2 x 6v @ 28 kgs each = 56 kgs
    Most deep cycle AGM types are around 30 kgs +/- ~4 kgs

    Big difference!
    -----
    You have the right to remain silent. Anything you say will be misquoted, then used against you.
    -----

    1999 Disco TD5 ("Bluey")
    1996 Disco 300 TDi ("Slo-Mo")
    1995 P38A 4.6 HSE ("The Limo")
    1966 No 5 Trailer (ARN 173 075) soon to be camper
    -----

  8. #8
    Homestar's Avatar
    Homestar is offline Super Moderator & CA manager Gold Subscriber
    Join Date
    Aug 2010
    Location
    Sunbury, VIC
    Posts
    20,055
    Total Downloaded
    0
    Quote Originally Posted by Fubar View Post
    Buy Trojan T-105 - Trojan Deep Cycle Batteries

    Well that's the nail on the head.

    Bloody hell I should know better! That's the 'catch', need to smack myself up the side of the head....I'm a moron. I got way too excited at the outcome and not the why.

    ah @ 12v = wh/v

    ah @ 6v =wh/v

    1200/12=100ah

    1200/6= 200ah


    Correct - power is power - the wattage of a given load stays the same - the current drawn is a different story. No free lunches here unfortunately.
    If you need to contact me please email homestarrunnerau@gmail.com - thanks - Gav.

Tags for this Thread

Bookmarks

Bookmarks

Posting Permissions

  • You may not post new threads
  • You may not post replies
  • You may not post attachments
  • You may not edit your posts
  •  
Search AULRO.com ONLY!
Search All the Web!