Page 1 of 3 123 LastLast
Results 1 to 10 of 27

Thread: Post your annoying rattles on the D2

  1. 17th December 2011, 10:07 PM #1
    It'sNotWorthComplaining! Guest

    Post your annoying rattles on the D2

    Please post your annoying D2 rattles and solutions

    Whilst underneath the disco,
    1. I noticed that the Silver heat protection panels underneath are only held on by a pin and a push on metal washer. You guess it when they wear loose they rattle.

    2.The heat shroud over the started motor rattles.

    3. the tin under the cats is spot welded on, when one end comes off, Rattle

    3. The rear seats rattle as the locking mechanism is not holding them tight.
    Reply With Quote Reply With Quote
  2. 17th December 2011, 10:10 PM #2
    banarcus's Avatar
    banarcus
    banarcus is offline Master
    Join Date
    Apr 2010
    Location
    Lower Hunter Valley NSW
    Posts
    313
    Total Downloaded
    0
    1. Sunroof, front and back rattle when fully opened.
    2. Seats 6 and 7 rattle on bumps whilst rounding a bumpy corner.
    3. Bent exhaust rattling on towbar thingy under the car from off road exploits.
    Reply With Quote Reply With Quote
  3. 17th December 2011, 10:31 PM #3
    Marmoset's Avatar
    Marmoset
    Marmoset is offline Master
    Join Date
    Jun 2010
    Location
    Perth, WA
    Posts
    429
    Total Downloaded
    0
    Engine cover buzzes on mine
    Reply With Quote Reply With Quote
  4. 17th December 2011, 10:31 PM #4
    Fluids's Avatar
    Fluids
    Fluids is offline YarnMaster Subscriber
    Join Date
    Mar 2009
    Location
    Port Stephens N.S.W
    Posts
    3,161
    Total Downloaded
    0
    Just one ...

    I've got a rattle in the rear trim above or somewhere near the two back doors ... only hear it over rough terrain or large bumps ... bit hard to track down when your driving !

    ... no solution as yet.
    Kev..

    2014 Isuzu MUX LST with fruit
    2008 Isuzu D-Max
    2015 Kimberley Kamper "Classic"

    Gone ... 2004 D2a Td5 Auto "Classic Country" Vienna Green
    Reply With Quote Reply With Quote
  5. 17th December 2011, 11:13 PM #5
    LOVEMYRANGIE's Avatar
    LOVEMYRANGIE
    LOVEMYRANGIE is offline YarnMaster
    Join Date
    Feb 2008
    Location
    Northern Windowlickersville WA
    Posts
    3,403
    Total Downloaded
    0
    Friggin' keys against the RH lower dash panel

    Using Capitals, the difference between helping your Uncle Jack off a horse or helping your uncle jack off a horse...
    Reply With Quote Reply With Quote
  6. 18th December 2011, 07:00 AM #6
    SiddersC's Avatar
    SiddersC
    SiddersC is offline Master
    Join Date
    Jan 2010
    Location
    Adelaide
    Posts
    601
    Total Downloaded
    0
    Turbo heat shield
    Glovebox lid - fixed
    Reply With Quote Reply With Quote
  7. 18th December 2011, 08:06 AM #7
    scarry's Avatar
    scarry
    scarry is offline Swaggie
    Join Date
    Apr 2008
    Location
    Brisbane,some of the time.
    Posts
    13,951
    Total Downloaded
    0
    Mine is pretty good although it has the wonderful drone at certain revs.

    one of the earlier one's i had had a shocking rattle in the dash.After a few trips to the dealer,it was under warranty,they found the heater hose was not clipped into the plastic bracket at the rear of the engine compartment.
    The hose was rubbing on the firewall & causing something in the dash to rattle
    FIXED
    Reply With Quote Reply With Quote
  8. 18th December 2011, 08:32 AM #8
    Jeff's Avatar
    Jeff
    Jeff is offline Wizard
    Join Date
    Sep 2006
    Location
    Northern Beaches
    Posts
    1,426
    Total Downloaded
    0
    1. Glovebox lid - solution, a folded piece of paper wedged in.
    2. Left rear seat when folded up - solution, leave seat down unless we need the space.

    The more annoying and more difficult to fix is the wind noise from the left rear door, the rest of the car is beautifully quiet.

    Jeff

    Reply With Quote Reply With Quote
  9. 18th December 2011, 08:38 AM #9
    OffTrack's Avatar
    OffTrack
    OffTrack is offline YarnMaster
    Join Date
    Feb 2011
    Location
    Brunswick, Victoria
    Posts
    3,778
    Total Downloaded
    0
    Squeaks and Rattles? There's a Tech Bulletin for that

    Squeaks and Rattles: Attachment 41632
    Centre Console: Excessive movement and rattles: Attachment 41633
    A Chattering Noise from the Centre Console Area/Handbrake: Attachment 41634
    Underfloor heatshield loose/rattling: Attachment 41635
    Last edited by OffTrack; 10th April 2012 at 05:32 AM.
    Reply With Quote Reply With Quote
  10. 18th December 2011, 08:50 AM #10
    OffTrack's Avatar
    OffTrack
    OffTrack is offline YarnMaster
    Join Date
    Feb 2011
    Location
    Brunswick, Victoria
    Posts
    3,778
    Total Downloaded
    0
    Quote Originally Posted by Marmoset View Post
    Engine cover buzzes on mine
    The oil filler hatch in the cover tends to rattle. I've stuck an offcut of a zip tie under the clip end to stop it vibrating. It's a bit ghetto but works.
    Reply With Quote Reply With Quote
Page 1 of 3 123 LastLast
« Brakes | XYZ Switch Contact Lube »

Bookmarks

Bookmarks

Posting Permissions

  • You may not post new threads
  • You may not post replies
  • You may not post attachments
  • You may not edit your posts
  •  

Forum Rules

Search AULRO.com ONLY!
 Search All the Web!