EGR delete.

Quote:

---

Originally Posted by Blknight.aus

no they arent.

they all remove and blank the same though.

2002 was the change year

---

Quote:

---

Originally Posted by scarry

Doesn't matter,just remove and blank,all good[bigrolf]

All you need to know is if same blank fits all[biggrin][bighmmm]

---

Someone's got to compensate for DiscoMick and his hotted up Defender. [bigwhistle]

Back on topic,i was reading today about the LC V8, 1VD-FTV, apparently the EGR's are used to help keep the engine warm under some conditions.

I wonder if thats correct?

Could be so, Paul. From the research I've done, it can be used to stabilise temps, heating when cold or cooling under operating conditions.

Quote:

---

Originally Posted by V8Ian

Thanks Ron, that would keep me on the right side of the Mikes. [wink11]

Do all versions of the TD5 use the same valve?

---

I thought we were on the same side.

Quote:

---

Originally Posted by DiscoMick

I thought we were on the same side.

---

Apart from the alloy header tank I recently fitted, my car is stock as a rock, no emission and performance increasing mods here.

The previous owner fitted the Steinbauer to our Defender, so my hands are clean. All care and no responsibility!

Quote:

---

Originally Posted by DiscoMick

The previous owner fitted the Steinbauer to our Defender, so my hands are clean. All care and no responsibility!

---

OK, so if I pay a mechanic to delete my EGR, my hands will be clean both literally and metaphorically, and I won't be responsible for killing 1,000 people a year? [bighmmm]

In another thread you explain your plans for running a generator, for air conditioning while camping. You must have a bigger (carbon) footprint than a yowie. All this while pushing the environmental barrow and judging others. Do you see the irony? [bigwhistle]

Quote:

---

Originally Posted by V8Ian

Could be so, Paul. From the research I've done, it can be used to stabilise temps, heating when cold or cooling under operating conditions.

---

The only cooling EGR performs is that by displacing oxygen in the cylinder it reduces combustion temps and hence NOx.

It probably could speed warm up and get emmissions under control a lot faster, too.

You can watch when it's called for on the Nanocom, even at part throttle but relatively high speed/load it can call for a % of EGR.

Quote:

---

Originally Posted by scarry

Back on topic,i was reading today about the LC V8, 1VD-FTV, apparently the EGR's are used to help keep the engine warm under some conditions.

I wonder if thats correct?

---

correct it can

Quote:

---

Originally Posted by V8Ian

Could be so, Paul. From the research I've done, it can be used to stabilise temps, heating when cold or cooling under operating conditions.

---

IT works by allowing the engine to run nearer to the the correct stoichiometric ratio. The closer you get to this the hotter the combustion temperature is (Diesel not petrol they need to lean out a bit but perversely overfuel to compensate for the colder conditions to ensure the fuel lights off and emit more emissions) once you got past it (more fuel than air for the mix) you start getting into pyrolytic combustion which is hotter again but more polluting (soot)

Quote:

---

Originally Posted by DiscoMick

I thought we were on the same side.

---

depends on how you want to define side.. Of the planetary crust? yes, of this debate? I dont care I'm on the fence for it as none of this eco-greenippy-warrior crap is applicable to anything I've got or will likely get so I can enjoy my typical position of firing randomly into the fray and not caring where the shots land.

:BigThumb:

Quote:

---

Originally Posted by V8Ian

OK, so if I pay a mechanic to delete my EGR, my hands will be clean both literally and metaphorically, and I won't be responsible for killing 1,000 people a year? [bighmmm]

In another thread you explain your plans for running a generator, for air conditioning while camping. You must have a bigger (carbon) footprint than a yowie. All this while pushing the environmental barrow and judging others. Do you see the irony? [bigwhistle]

---

The generator is mainly for charging batteries when remotely camped, but I'm adding capacity for the air-con just because The Navigator reckons its a good idea, and I'm a firm believer in Happy Wife = Happy Life! [emoji41]

I don't think paying someone else to make your vehicle illegal makes any difference to who is responsible, but whatever floats your boat is not my problem, so go for it if you wish.
Of course, you're not personally responsible for killing 1000 people a year - we're all doing our bit to ruin the only planet we have.