Thread: Won't go over 60km/h

Originally Posted by oscarcharliezulu

I had the same problem and it was the part that burns the particulates captured from your diesel emissions. ....

I don't think you have a TD5 then ... no particulate burning process.

Originally Posted by eckolsim

Don't forget to check the vacuum line to the turbo boost regulator.

HX 52: TD5 D2 engine - Wastegate Modulator (1)

If this is cracked/perished you won't go anywhere fast.

Yep - had exactly same problem a few years ago - faulty waste gate modulator

Originally Posted by sierrafery

Before you order one make sure it's not a voltage drop on the circuit cos it can happen

I bit the bullet and just ordered a new one before i saw this post. Figured everything points to that and the fuel pump to my knowledge, has never been replace and the car has 250,000km so its a worthy gamble.

Also for everyone else, i checked all the vacuum hoses and turbo hoses and they seem fine, though after this i probably will just change all the lines and hoses as it sounds like they will most like stuff up one day as well.

Noisy, the system is still able to pull fuel from the tank even with a faulty pump. It is the cam on the injectors that generate the pressure to spray the diesel in the cylinders. It is just that without a fuel pump the system can’t cope with larger volumes of fuel demand. Usually it will drive along at dirt road speeds but when on the paved roads the system can’t cope with the additional demand. In neutral the engine can rev as it can do it with little fuel.

Car is back to new. Runs really well has plenty of power again. Only problem i have is the fuel gauge goes from full to dead empty and back to full, seem to relate with the sloshing in the tank. Doesnt do it all the time just every now and again I filled it up to see if that would fix it but it still does it.

Originally Posted by Noisy

Car is back to new. Runs really well has plenty of power again. Only problem i have is the fuel gauge goes from full to dead empty and back to full, seem to relate with the sloshing in the tank. Doesnt do it all the time just every now and again I filled it up to see if that would fix it but it still does it.

Fuel pump then?

Originally Posted by Noisy

Car is back to new. Runs really well has plenty of power again. Only problem i have is the fuel gauge goes from full to dead empty and back to full, seem to relate with the sloshing in the tank. Doesnt do it all the time just every now and again I filled it up to see if that would fix it but it still does it.

Seems that your new pump has a faulty level sender if it didnt happen with the old pump... you can swap the sender from that one

Originally Posted by shack

Fuel pump then?

Yeah was the fuel pump