Results 1 to 7 of 7

Thread: 95 D1 rear springs

  1. 16th December 2008, 08:17 AM #1
    Boxhead63 Guest

    95 D1 rear springs

    I'm on my third set of rear springs on my D1. They've been replaced twice,under warranty each time with a heavier rated spring but again after a few decent drives the right rear sags again. Any suggestions?????????

    Cheers Rob
    Reply With Quote Reply With Quote
  2. 16th December 2008, 02:07 PM #2
    discopete's Avatar
    discopete
    discopete is offline Master Silver Subscriber
    Join Date
    Sep 2007
    Location
    Hobart
    Posts
    643
    Total Downloaded
    0
    You could try a spring spacer, or order a custom set of springs with extra length in the sagging side.
    Oh, meant to ask what brand spring are you using. My rear has just gone like that but have been using springs for about 3 years and 60k road and offroad kms. Shouldn't happen after a few trips, sounds like poor quality springs.

    Pete
    Reply With Quote Reply With Quote
  3. 16th December 2008, 02:33 PM #3
    jmkoffice
    jmkoffice is offline Master
    Join Date
    Jan 2008
    Location
    4510 QLD
    Posts
    264
    Total Downloaded
    0
    Fit Polyair's Mate. cost $345ish and 1 - 2 hours to fit. You won't have a sag problem again.
    Reply With Quote Reply With Quote
  4. 16th December 2008, 06:35 PM #4
    streaky Guest
    What springs are you using? Changing poor quality springs for another set of poor quality ones under warranty won't fix the problem (as you've found out)

    I've had Dobinson springs on the back end for the past four years and they don't show any signs of sagging....& I carry alot of weight too!

    The use of Air Bags will help resolve the problem but fitting good springs in the first place means that you don't nessesarily have to fork out $345 for them!
    Air Bags may increase your rear load carrying capacity....but they shouldn't be fitted to cure poor quality springs IMHO.

    Regards.

    S.
    Reply With Quote Reply With Quote
  5. 16th December 2008, 07:07 PM #5
    Slunnie's Avatar
    Slunnie
    Slunnie is online now Swaggie Gold Subscriber
    Join Date
    Jan 1970
    Location
    Central West NSW
    Posts
    14,147
    Total Downloaded
    99.87 MB
    I think the airbags will jsut be a mask. It sounds like the springs are the problem.

    Are the springs sided? ie the drivers side springs are taller? LandRovers seem to have a rea problem with the drivers side being lower than the passengers side. The drivetrain seems to be heavier on that side.
    Cheers
    Slunnie


    ~ Discovery II Td5 ~ Discovery 3dr V8 ~ Series IIa 6cyl ute ~ Series II V8 ute ~
    Reply With Quote Reply With Quote
  6. 16th December 2008, 10:39 PM #6
    hook's Avatar
    hook
    hook is offline Master
    Join Date
    Jan 1970
    Location
    N Qld,
    Posts
    702
    Total Downloaded
    0
    King Springs

    STD rate spring, very comfy on-off road.
    Put air in my Poly bags, for use with trailer, or heavy load in the rear.
    Dose't over load springs, 5 years now.

    Better the driving around in a tank wtih HD springs.
    Reply With Quote Reply With Quote
  7. 17th December 2008, 10:09 AM #7
    trobbo's Avatar
    trobbo
    trobbo is offline Master
    Join Date
    Jan 1970
    Location
    Warrandyte, vic
    Posts
    920
    Total Downloaded
    0
    Springs are usually rated the same and sold in pairs. front & rear will be different but left to right will be the same. Interesting that you have had the same side go on two occaisions. Do you have extra equipment on the RHS which would require a heavier spring eg fuel tanks?

    A good quality spring should not fail so quickly. As indicated air bags or coil spacers will help but are masks of the problem. Whether it be a requirement for a heavier spring on that side or the replacement of dud springs.
    Reply With Quote Reply With Quote
« help urgently needed | ignition coils »

Bookmarks

Bookmarks

Posting Permissions

  • You may not post new threads
  • You may not post replies
  • You may not post attachments
  • You may not edit your posts
  •  

Forum Rules

Search AULRO.com ONLY!
 Search All the Web!