Reply With QuoteHi, even if the bulletin is called "Fuel Door Fails to Open" it refers to "FUEL DOOR DOES NOT PROPERLY LATCH OR UNLATCH" so might be usefull: https://landroverclubvi.weebly.com/u...ls_to_open.pdf
My fuel door will not stay closed , went to put fuel in this arfo ,pressed the button on dash to open it all well ,when i went to close it it would not shut , the pin is working as it should when pressing button, what i have on door is a latch but thats it ,it moves freely but i think there may be a spring missing but all the spare part pics i have seen dont show one . any help if i can get a pic i will post tomorrow ,
YarnMaster
Hi, even if the bulletin is called "Fuel Door Fails to Open" it refers to "FUEL DOOR DOES NOT PROPERLY LATCH OR UNLATCH" so might be usefull: https://landroverclubvi.weebly.com/u...ls_to_open.pdf
Discovery Td5 (2000), manual, tuned
AT RESTinside the fuel door compartment on the left hand side is a little black plastic clip this catches and holds the door flap in the closed position, they are notorious for breaking.
s-l300.jpg BPX700010
OldBushie
SupporterThe secret when fitting a new fuel door plastic clip is to put it in a mug of boiling water for a few seconds before pushing it into position.
If you fit them "cold" you stand a good chance of buggering up the little clip that goes into the hole when you fit it
You only get one shot at life, Aim well
2004 D2 "S" V8 auto, with a few Mods gone
2007 79 Series Landcruiser V8 Ute, With a few Mods.
4.6m Quintrex boat
20' Jayco Expanda caravan gone
Fossicker
Mine wouldn't shut after refuelling one time, plastic bit wasn't broken, turned out that I had hit the metal tab the plastic bit is with the fuel nozzle. Slight bend of tab towards rear fixed it.
Master
Most likely causes:
1/ You have closed the cap to position it fouls the door. Yes. turn the cap a quarter turn and it will close
2/ you bent the tab inwards with the filler. bend it back a bit.
It could be missing the wee plastic thing - but I'm laying good odds you will be "Doh!" when you go and look :0
Master
Supporterhappens to me all the time, mine is i don't screw the lid on far enough. Keep turning the lid until the door can shut, that is if that is the problem and nothing else
2000 Discovery 2 td5 Auto (Sandy)
2" dobinsons springs and bilstein shock,
Arb steel winch bar, homemade rear drawers,
steel rear bar
7" Led spotties, Roo systems awning, 3 cross bar roof racks
265/70R16 Falken Wildpeak AT3W
Thanks for all the info, got it fixed ,it was the steel tab the clip was connected to,it had been ht by my fat gut ,and needed pushed forward ,so easy fix
| Search AULRO.com ONLY! |
Search All the Web! |
|---|
|
|
|
Bookmarks