Thread: What happened to your D3/D4 today?

Originally Posted by 101RRS

Last week I had metal on metal contact on front right brake.

On removal front outer was metal on metal, front inner was still 4mm. Usual cause is caliper not sliding but I reassembled with out pads and the caliper slid no issue and the pins were all still greased from last pad change.

The front passenger side brake with the sensor are still 4mm so no issues there. My only guess is that the disk or pad on the right outer had an issue.

Garry

Even if the calipers slide freely, there's a good chance the piston inside doesn't move all that well. Drain and remove the pistons, fit new seals and fill, bleed and should be good to go. Did mine when I replaced all thr 10yo rubber hoses, the back of the pistons were gummed up with the inside of the old hoses.

Originally Posted by Eric SDV6SE

Even if the calipers slide freely, there's a good chance the piston inside doesn't move all that well. Drain and remove the pistons, fit new seals and fill, bleed and should be good to go. Did mine when I replaced all thr 10yo rubber hoses, the back of the pistons were gummed up with the inside of the old hoses.

Make sure you open the kits when they arrive, island sent me trw kits that were missing the dust boots, I had to reuse and order another set. Not their fault. They were unopened. They still didn't want to know me but.

So I've been stupidly busy for a while now and had a strange apple smell in the Disco. Nothing bad, I quite like apples, but it wasn't there last 6 years and doesn't go away.
I keep a clean car, regularly vacuum, clean the leather etc.
Obvious thing is a forgotten apple, but couldn't find one.
Well guess what I found today... yep half rotten in the rear seat well under the 3rd row of seats.

Lesson- look for the obvious solution..

My wife is 'Mrs Houseproud' if I leave anything out in the house - but her ability to hide assorted pieces of rotting fruit in cars is extraordinary... Apple cores, banana skins, orange peel. You name it, its been left to 'sweeten the aroma' in our cars. I love finding it by touch when my fingers plunge into a rotting mulch as I reach for a pen or whatever in various storage locations....

Originally Posted by Jpdv

My wife is 'Mrs Houseproud' if I leave anything out in the house - but her ability to hide assorted pieces of rotting fruit in cars is extraordinary... Apple cores, banana skins, orange peel. You name it, its been left to 'sweeten the aroma' in our cars. I love finding it by touch when my fingers plunge into a rotting mulch as I reach for a pen or whatever in various storage locations....

Luckily you dont have rats around.

A mate had them chew through the plastic fresh air grill,then through the filter,then into the glovebox and ate all of the 25 minties,that were in an unopened packet.

And all that happened in one night.

Wife was heading out and told me a large tree branch came down on the my car, just clipped the tailgate and broke the bloody back wiper again - only just replaced the motor earlier this yearafter some timber fell back and stripped the plastic gears in the motor .

I found some STL files to 3D print a gear so hopefully they are the same between disco and RR.

Originally Posted by JAR1

Attachment 181416

OUCH! - 2.7L 165k on it

S zzzzzzzzzzzzzzzzzzzzzzsszzzzzzzzzz5ss

Originally Posted by loanrangie

Wife was heading out and told me a large tree branch came down on the my car, just clipped the tailgate and broke the bloody back wiper again - only just replaced the motor earlier this yearafter some timber fell back and stripped the plastic gears in the motor .

I found some STL files to 3D print a gear so hopefully they are the same between disco and RR.

Link? I’m guessing Thingiverse?