Page 1 of 2 12 LastLast
Results 1 to 10 of 11

Thread: TD5 Automatic Transmission - removing electrical connections and top oil line

  1. #1
    Join Date
    Feb 2011
    Location
    Hobart, Tasmania, Australia
    Posts
    3,828
    Total Downloaded
    0

    Question TD5 Automatic Transmission - removing electrical connections and top oil line

    Since I have a strong record of breaking the clips on electrical connection plugs, I thought I'd ask before attempting.
    On the top of the automatic transmission are some black round electrical connection plugs, they're up high and I can't see a clip or straight forward way of disconnecting them - whats the secret please?

    And the top oil cooler line fitting, what's the best way to attack that? The bottom one was easy with a 19mm crowfoot on the end of a 3/4" 6" extension and ratchet.

  2. #2
    Join Date
    Dec 2009
    Location
    Hampton Park
    Posts
    480
    Total Downloaded
    0
    Hello twr7cx,

    Slide a small electrical terminal screwdriver between the metal bracket and the plastic clip. This disengages the little tab that is holding the terminal to the bracket.( so while you have the screwdriver in behind the tab, jiggle it a bit and then wiggle the the plastic terminal).
    I hope that makes some sort of sense

    I had my transmission out last week, that's what worked for me.

    Cheers,

    Jason

    PS. Use an open ender for the line on the side of the transmission(and the bottom line also for that matter). Do get new O rings when you put them back
    Last edited by Jason789; 14th September 2012 at 08:27 PM. Reason: The PS.

  3. #3
    Join Date
    Feb 2011
    Location
    Hobart, Tasmania, Australia
    Posts
    3,828
    Total Downloaded
    0

    Question

    Between the passenger side chasis rail and the automatic transmission:


    Inhibitor switch connection looks like it first needs to be disconnect from it's mount tab and then the disconnected:




    How is this black cylinder electrical connection disconnected? Looks as though it be be unscrewed?
    Note the two black flat terminal connections floating loose (one has a black wire with green stripe), they were not connected to anything, is that an issue? Should they have been?





    Transfer box from the front:

    How do these get removed?





    Can I place a jack under the transmission, remove the two rear mounts and lower it down a bit to increase working area or would this overstress the front engine mounts?



    EDIT: inhibitor switch and transmission fluid cooler lines are disconnected. Just the black cylinder connection on the automatic transmission and the transfer box connections holding me up now. And the top drivers side bellhousing bolt.

  4. #4
    Join Date
    Feb 2011
    Location
    Brunswick, Victoria
    Posts
    3,778
    Total Downloaded
    0
    Have a look at the Auto Transmission TB attached to this post:

    http://www.aulro.com/afvb/discovery-...ml#post1704941

    It is a revised version of the auto removal procedure in RAVE. It should answer every question you've asked in this thread so far

    For example:

    32. Rotate the locking ring anti-clockwise and disconnect the transmission connector.

    40. Raise the transmission and remove the two transmission mounting bracket assemblies.
    41. Lower the transmission sufficiently to access the top of the transmission.

    42. To prevent damage to components, cushion the jack pad with a block of wood or hard rubber.
    Position a second support jack under the engine using a block between the engine sump and jack to prevent damage to the sump.
    cheers
    Paul

  5. #5
    Join Date
    Feb 2011
    Location
    Hobart, Tasmania, Australia
    Posts
    3,828
    Total Downloaded
    0
    Is there anywhere to get ALL the TB's since Rave was released?

  6. #6
    Join Date
    Feb 2011
    Location
    Hobart, Tasmania, Australia
    Posts
    3,828
    Total Downloaded
    0
    Cheers for the TB, but it is still quiet vague.

    I'm still have difficulty with the black cylinder electrical connection. I can get my hand on it, but it doesn't turn either way. The TB says anti-clockwise, which is stupid, as that is a subjective term, anti-clockwise when facing which way? Also, if you look at the picture I put up earlier, there are two parts that are knurled, I assume its the part closes to the transmission that I turn, but not really sure, could have to turn both to unscrew them from each other?


    It's frustrating having just these few connections holding me up from dropping the box. Out of daylight now anyways though. I'm pretty confident that there is enough slack in the cables to lower the back of the box down a bit (hopefully the engine mounts will survive) and this hopefully will allow me to actually see what I'm disconnecting and get to it.

  7. #7
    Join Date
    Aug 2006
    Location
    Kingston, Tassie, OZ.
    Posts
    13,728
    Total Downloaded
    0
    Hi scott,

    That large cylindrical wiring harness plug; rotates as if you are undoing it IE Anticlockwise when viewed from behind looking forward. It only rotates about 90 degrees and pulls out IIRC. You have to rotate the collar that is right in close to the casing, not the outer one.

    I have a sump pan corner clamp here for you, too.

    JC
    The Isuzu 110. Solid and as dependable as a rock, coming soon with auto box😊
    The Range Rover L322 4.4.TTDV8 ....probably won't bother with the remap..😈

  8. #8
    Join Date
    Feb 2011
    Location
    Brunswick, Victoria
    Posts
    3,778
    Total Downloaded
    0
    Quote Originally Posted by twr7cx View Post
    Is there anywhere to get ALL the TB's since Rave was released?
    Yes. You can purchase a 24 hour subscription to D2 TB section on Topix and download them, which is how I got the ones I have.

    http://topix.landrover.jlrext.com

  9. #9
    Join Date
    Feb 2011
    Location
    Hobart, Tasmania, Australia
    Posts
    3,828
    Total Downloaded
    0
    All disconnected now. Probably the most frustrating and time consuming part of this job! Definitely the best way is to lower it down a bit, might not be nice for the front engine mounts though...

  10. #10
    jan v b Guest

    2004 auto gearbox wiring harness.

    My gearbox is giving fault codes like, speed sensor on gearbox (intermittent), gearbox temp sensor (intermittent, and a couple of other gearbox related codes. Do anyone know were the gearbox wiring plugs to the main harness or maybe other plugs were I might find bad contact on plugs?

Page 1 of 2 12 LastLast

Bookmarks

Bookmarks

Posting Permissions

  • You may not post new threads
  • You may not post replies
  • You may not post attachments
  • You may not edit your posts
  •  
Search AULRO.com ONLY!
Search All the Web!