Page 1 of 2 12 LastLast
Results 1 to 10 of 15

Thread: Restricted Performance in D4. Error code P2264.

  1. 15th August 2016, 06:49 PM #1
    wombathole's Avatar
    wombathole
    wombathole is offline Master
    Join Date
    Jan 2010
    Location
    Mont Albert, Victoria
    Posts
    143
    Total Downloaded
    0

    Restricted Performance in D4. Error code P2264.

    Was having a warning lamp and error message "Restricted Performance" on the dash. Iidtool said the fault was a PCM P2264. "Water in Fuel Sensor".

    1. Removed the gearbox cover.
    2. Removed the metal cover in front of the diesel fuel filter.
    3. Undid the yellow screw from the bottom of the fuel filter.
    4. Turned on ignition. (Turned on fuel pump. )
    5. A few drops of oily water came out of filter.
    6. Turned off ignition.
    7. Replaced screw and covers.

    So far so good, no more error messages or faults in computer.

    FYI. Andy.
    Reply With Quote Reply With Quote
  2. 15th August 2016, 07:03 PM #2
    sheerluck Guest
    At least you got a nice easy one Andy!
    Reply With Quote Reply With Quote
  3. 15th August 2016, 08:06 PM #3
    LRD414's Avatar
    LRD414
    LRD414 is offline Super Moderator Subscriber
    Join Date
    Oct 2014
    Location
    Brisbane
    Posts
    3,737
    Total Downloaded
    0
    Was the yellow screw difficult to undo?

    Cheers,
    Scott
    D4 TDV6 MY14 with Llams, Tuffant Wheels, Traxide DBS, APT sliders & protection plates, Prospeed Winch Mount w/ Carbon 12K, Mitch Hitch & Drifta Drawers
    Link to my D4 Build Thread
    D3 2005 V8 Petrol
    Ex '77 RRC 2 door. Long gone but not forgotten.
    Reply With Quote Reply With Quote
  4. 15th August 2016, 08:16 PM #4
    wombathole's Avatar
    wombathole
    wombathole is offline Master
    Join Date
    Jan 2010
    Location
    Mont Albert, Victoria
    Posts
    143
    Total Downloaded
    0
    Not too tight. Got it off with my fingers. I had replaced the fuel filter about 20k ago.
    Reply With Quote Reply With Quote
  5. 16th August 2016, 02:43 PM #5
    bbb's Avatar
    bbb
    bbb is offline Fossicker
    Join Date
    Jan 1970
    Location
    Huon Valley, TAS
    Posts
    37
    Total Downloaded
    0
    I had Restricted Performance with the same code in my D4 a little while back.
    Started off with checking for water in the fuel.
    Then replaced the fuel filter,
    Then replaced the fuel sensor,
    Alert still came up.
    Ended up needing to replace the fuel sensor housing - some kind of electrical issue.
    Alert has never come back.
    Reply With Quote Reply With Quote
  6. 19th August 2016, 07:10 PM #6
    wombathole's Avatar
    wombathole
    wombathole is offline Master
    Join Date
    Jan 2010
    Location
    Mont Albert, Victoria
    Posts
    143
    Total Downloaded
    0
    Thanks bbb.
    The alarm came back and I've bought a new fuel filter.
    Feels like I'm on a road you have travelled.

    The sensor housing? Is that the black plastic thing that the fuel filter screws into?
    Reply With Quote Reply With Quote
  7. 19th August 2016, 07:55 PM #7
    LandyAndy's Avatar
    LandyAndy
    LandyAndy is offline RoverLord Gold Subscriber
    Join Date
    Feb 2004
    Location
    Williams West Aust
    Posts
    20,998
    Total Downloaded
    0
    Tried cleaning the sensor????
    We get the fault on earthmoving gear too.The spannerman just sprays the sensor with CRC or similar if there is no water in the trap,usually fixes it.
    Andrew
    DISCOVERY IS TO BE DISOWNED
    Midlife Crisis.Im going to get stuck into mine early and ENJOY it.
    Snow White MY14 TDV6 D4
    Alotta Fagina MY14 CAT 12M Motor Grader
    2003 Stacer 525 Sea Master Sport
    I made the 1 millionth AULRO post
    Reply With Quote Reply With Quote
  8. 20th August 2016, 05:27 AM #8
    Graeme
    Graeme is offline Swaggie Vendor
    Join Date
    Jan 1970
    Location
    NSW SW Slopes
    Posts
    12,033
    Total Downloaded
    0
    I swapped just the electronic module rather than the whole housing to avoid risking contamination of the lines.
    MY21.5 L405 D350 Vogue SE with 19s. Produce LLAMS for LR/RR, Jeep GC/Dodge Ram
    VK2HFG and APRS W1 digi, RTK base station using LoRa
    Reply With Quote Reply With Quote
  9. 20th August 2016, 06:56 AM #9
    scarry's Avatar
    scarry
    scarry is offline Swaggie
    Join Date
    Apr 2008
    Location
    Brisbane,some of the time.
    Posts
    13,886
    Total Downloaded
    0
    With a simple issue like that,wouldn't you think a message on the dash readout would be the go,particularly for remote area travel.

    Many vehicles have an orange light on the dash to indicate water in fuel.
    Reply With Quote Reply With Quote
  10. 20th August 2016, 09:32 AM #10
    Grentarc
    Grentarc is offline Master Subscriber
    Join Date
    Aug 2015
    Location
    Coolamon, NSW
    Posts
    783
    Total Downloaded
    0
    Quote Originally Posted by scarry View Post
    With a simple issue like that,wouldn't you think a message on the dash readout would be the go,particularly for remote area travel.

    Many vehicles have an orange light on the dash to indicate water in fuel.
    My D4 (with updated dash software from the IID Tool) comes up with "Water in fuel" warning, then press OK to acknowledge, then the orange triangle remains, but no restricted performance yet - Whenever I go through a deep puddle and some water gets up there it throws this message - I really need to get under there and fix that!
    - Justin
    Selling soon - MY10 D4 3.0 TDV6 SE with E-Diff & LLAMS, 265/65R18 Maxxis Razr A/T
    Moved into MY12 L322 4.4 TDV8 Autobiography
    VK2HFJ
    Reply With Quote Reply With Quote
Page 1 of 2 12 LastLast
« I didn't know that the D4 could do THIS. | Alarm going off ?? »

Bookmarks

Bookmarks

Posting Permissions

  • You may not post new threads
  • You may not post replies
  • You may not post attachments
  • You may not edit your posts
  •  

Forum Rules

Search AULRO.com ONLY!
 Search All the Web!