Thread: Suspension Faults

It's definitely not a leaky strut?

My comp is still going ok 2007 RRS , i purchased a Dunlop compressor $479 from LRDirect as a spare when needed , cant be bothered with the soft ware change and the high price of the AMK .

Originally Posted by Stuart02

It's definitely not a leaky strut?

I think if it were a leaky strut that side would be dropping over a period of time and the fault code would be back.

Unless you can have a leaking strut and it not drop down?

Cheers

Garry

Originally Posted by garrycol

I think if it were a leaky strut that side would be dropping over a period of time and the fault code would be back.

Unless you can have a leaking strut and it not drop down?

Cheers

Garry

One of mine was throwing up suspension faults but obviously didn't have a big enough split to sag. I only knew it was that corner cos the other three had been replaced

Just a bit of a follow up - since the two faults and then me raising and lowering the car over the full height range I have not had any issues at all. In that time I have covered about 1200km and checked the codes today and there are none - not even communications errors.

While the compressor is still running Ok I might do the rebuild as a precautionary measure so hopefully get a few more years.

Cheers

Garry

This problem has not come back at all so not sure what was going on - so didn't bother rebuilding the compressor at this stage.

However last week the rear suspension went down to the bump stops overnight on a couple of occasions - only at night and not in the day. As it went down evenly on both sides an air leak in the airbags is unlikely. So was figuring the rear valve block might have leaks. However I went 4wding on the weekend with lots of extended and super extended height work (LLAMS) and since I have been back the suspension has not dropped.

So clearly not an airleak - I guess maybe an electrical issue when the car goes to sleep.

So open to suggestions - as indicated, has not dropped since a lot of use of the air suspension system.

This problem has happened once before about 18 months ago when the battery was dying but not had an issue since a new battery was installed.


Thanks

Garry

My L322 goes down at the front overnight but it can be spotted part-way down late in the day. I have purchased a valve block rebuilt kit as I expect that air is escaping from the cross-link valve. The cross-link valves get very little air flowing through them normally but a good dose of cross-articulation can clean-out the seals. I suspect that pulverised desiccant from mine's Hitachi dryer has found its way into the front cross-link valve and that the cross-link valve seal to atmosphere also isn't sealing well. I hope to rebuild the valve block in a week or 2.

Graeme - thanks - where did you get your rebuild kit from? If mine starts playing up again I will pull the EAS fuse to see if the issue is electrical or a leak and if a leak I will try rebuilding my rear valve.

Cheers

garry